1、 Improper operation by the driver. Why is it that the driver did not operate properly? Mixer is a special vehicle, which has a history of more than ten years in China. Most drivers are novices in driving mixer. Many drivers have been driving trucks for more than ten years, but driving cement mixers is a novice. Concrete mixer truck is different from ordinary truck, because the cement mixing tank rotates constantly during driving. If you don't control the speed and the speed of the tank when turning or the road is bad, it's easy to overturn. This has nothing to do with the quality of the car.

二、路况恶劣。好多水泥搅拌车在工地上使用，有的工地路况特别恶劣。上次听一个客户说一个工地地面堆了1米多的石子，有的地方速度慢了很容易把车陷进去，必须快速的冲过。

2、 Bad road conditions. Many cement mixers are used on construction sites, and the road conditions on some construction sites are particularly bad. Last time I heard a customer say that more than 1m stones were piled on the ground of a construction site. In some places, the speed was slow, it was easy to sink the car in, and we had to rush through it quickly.

混凝土搅拌车本身就是一种低速行驶的车辆。如果碰到这样的工程宁可不要接这样的活，还没有做多久车就翻了，就亏大了。

The concrete mixer itself is a low-speed vehicle. If you encounter such a project, you'd rather not take such a job. Before long, the car turns over and loses a lot.

三、如何避免翻车。水泥搅拌车重载时一定要注意 ，发动机转速在1000-1400转/分范围内工作，以使发动机有扭距，在运送混凝土过程中，车速不得超过40km/h，以保行车安全。转弯时一定要在直路上先减速，然后再转弯。(大部分翻车都是在转弯时发生)搅拌车装运搅拌好的混凝土时，搅拌筒转速为2-10转/分。

3、 How to avoid rollover. When the cement mixer truck is overloaded, it must be noted that the engine speed is within the range of 1000-1400 rpm to make the engine have the maximum torque. During the transportation of concrete, the speed shall not exceed 40km / h to ensure driving safety. When turning, be sure to slow down on the straight road before turning. (most rollovers occur when turning) when the mixer transports the mixed concrete, the speed of the mixing drum is 2-10 R / min.

在运输过程中，平坦路面上搅拌筒转速保证在2-3转/分，行驶在侧倾坡度大于50的路面，或左右晃动较大的路面时，应停止搅拌旋转，待路况好转后再恢复搅拌旋转。

During transportation, the rotating speed of the mixing drum on a flat road shall be 2-3 rpm. When driving on a road with a roll gradient greater than 50 or a road with large shaking left and right, the mixing rotation shall be stopped and resumed after the road conditions improve.

以上的精彩内容就是小编今天为您提供的内容，更多的精彩内容来自：全自动混凝土搅拌车详情请点击我们的网站关注：

The above wonderful content is what Xiaobian provides for you today. More wonderful content comes from: automatic concrete mixer. For details, please click our website to pay attention to: Cement self loading mixer