1.自上料搅拌车，每天检查各转动部位润滑点的工作情况，及时补给润滑油。
1. From the loading mixer truck, check the working conditions of the lubrication points of each rotating part every day and replenish the lubricating oil in time.
2.自上料搅拌车，每天检查搅拌机润滑油杯内润滑油量，及时补给润滑油。
2. From the loading mixer, check the amount of lubricating oil in the lubricating oil cup of the mixer every day and replenish the lubricating oil in time.
3.每周检查一次气路系统上的油雾器的油面高度，使用粘度为2.5~7°E的润滑油。
3. Check the oil level of the oil atomizer on the air circuit system once a week and use lubricating oil with viscosity of 2.5 ~ 7 ° E.
4.每天在开机前和关机后打开一次排水阀，将空气压缩机和储气罐内凝聚的水排出。
4. Open the drain valve once a day before startup and after shutdown to discharge the condensed water in the air compressor and air storage tank.
5.紧固件比如螺栓和螺母，要每周检查是否松动，发现有松动时，必须及时拧紧，尤其是一些受变幅载荷的零部件。
5. Fasteners such as bolts and nuts should be checked weekly for looseness. If looseness is found, they must be tightened in time, especially some parts under variable amplitude load.

6.每天经常检查供水、供气及外加剂系统的各设备是否正常。
6. Regularly check whether the equipment of water supply, gas supply and admixture system is normal every day.
7.每天检查电气控制系统及各仪表是否正常。
7. Check whether the electrical control system and instruments are normal every day.
8.每天检查搅拌机的搅拌轴和整体是否干净清洁，如果搅拌轴上凝结的混凝土过多，必须人工进入清理。
8. Check whether the mixing shaft and the whole of the mixer are clean every day. If there is too much concrete on the mixing shaft, it must be cleaned manually.
9.每半年清理或更换粉料罐除尘器中的过滤网。清理粉料罐除尘器中的过滤网时不能水洗，只能用气吹或软毛刷清理。自上料搅拌车，若停机时间超过一周以上的，必须放空各计量斗内的物料，如水泥、水、外加剂及各种骨料，并清洗搅拌主机，出料斗等处，以免物料板结。
9. Clean or replace the filter screen in the dust collector of the powder tank every six months. When cleaning the filter screen in the dust remover of the powder tank, it cannot be washed with water, but can only be cleaned with air blowing or soft bristle brush. If the shutdown time of the self loading mixer exceeds one week, the materials in each metering bucket, such as cement, water, admixture and various aggregates, must be emptied, and the mixing host and discharge hopper must be cleaned to avoid material hardening. 上就是今天全自动混凝土搅拌车

分享名称：混凝土搅拌车怎么做好日常检查及相关事项！
当前网址：/hangye/sdjbc/n67333.html

声明：本网站发布的内容（图片、视频和文字）以用户投稿、用户转载内容为主，如果涉及侵权请尽快告知，我们将会在第一时间删除。文章观点不代表本网站立场，如需处理请联系客服。电话：028-86922220；邮箱：631063699@qq.com。内容未经允许不得转载，或转载时需注明来源： 创新互联