全自动搅拌车发动机预热前的检查（一）

Inspection before preheating the engine of full-automatic mixer truck (I)

1、检查液压油的存储量是否充足。（即检查油位的存储器）

1. Check whether the storage volume of hydraulic oil is sufficient. (i.e. memory for checking oil level)

2、检查减速器的润滑油有无泄露。

2. Check whether the lubricating oil of the reducer leaks.

3、检查液压系统的液压油有无泄露，各接头部位是否有渗漏现象。

3. Check whether the hydraulic oil of the hydraulic system leaks and whether the joints leak.

4、检查搅拌车操纵装置的操纵手柄有无置于停止（stop）位置。

4. Check whether the control handle of the mixer truck control device is in the stop position.

5、检查各连接紧固件不能有松动现象。

5. Check whether all connecting fasteners are loose.

全自动搅拌车发动机预热前的检查（二）

Inspection before preheating of engine of full-automatic mixer truck (II)

1、检查油泵是否有异常声音。

1. Check whether the oil pump has abnormal sound.

2、检查液压马达有无异常声音。

2. Check the hydraulic motor for abnormal sound.

3、检查减速器有无异常声音。

3. Check the reducer for abnormal sound.

4、检查水泵是否有正常转动。

4. Check whether the water pump rotates normally.

5、检查搅拌车的进料回转装置是否正常，能否进行正常的工作回转。

5. Check whether the feeding rotary device of the mixer truck is normal and whether it can rotate normally.

6、就是检查搅拌车的辅助卸料槽的锁扣、卸料槽的锁柄、防转手柄是否锁紧。

6. Check whether the lock catch of the auxiliary discharge chute of the mixer, the lock handle of the discharge chute and the anti rotation handle are locked.

全自动搅拌车发动机预热前的检查（三）

Inspection before preheating the engine of full-automatic mixer truck (III)

检查搅拌车火花塞是否损坏。如果损坏，只要更换新火花塞即可。一般来讲，搅拌车的火花塞使用里程大约2万~3万公里。检查蓄电池电压是否足够。很多蓄电池设计了用于检测的观察孔，呈现绿色的时候，可以正常使用，出现黑色，需要补充点或者维护，出现白色，电瓶该更换了。

Check whether the spark plug of the mixer truck is damaged. If it is damaged, just replace it with a new spark plug. Generally speaking, the service mileage of the spark plug of the mixer truck is about 20000 ~ 30000 km. Check whether the battery voltage is sufficient. Many batteries are designed with observation holes for detection. When they are green, they can be used normally. They appear black and need to be supplemented or maintained. When they appear white, the batteries need to be replaced.

停车忘记关灯，就可能耗尽电源。如果是这样，拧动点火开关在ON的位置，把车挂二挡，脚踩离合，用车拖拽，当行驶到一定速度时，松开离合，汽车就能自然启动。这种办法适用于仅仅是电力不足的故障，如果是点火系统有问题，此法不但不能奏效，可能还对三元催化器有坏的作用，还有的车会损坏正时皮带，导致严重的机械故障。安装自动变速箱的车，不能推车启动，可用跨接电缆连接另一辆车的蓄电池启动发动机。

If you forget to turn off the lights when parking, you may run out of power. If so, turn the ignition switch to the on position, shift the car to the second gear, step on the clutch and drag the car. When the car reaches a certain speed, release the clutch and the car will start naturally. This method is applicable to the fault of insufficient power. If there is a problem with the ignition system, this method will not work. It may also have a bad effect on the three-way catalyst. Some cars will damage the timing belt, resulting in serious mechanical failure. The vehicle with automatic transmission can not be started by cart. The engine can be started by connecting the battery of another vehicle with jumper cable.

以上就是问题解答的相关内容了，希望能够帮助到大家，如对这一问题还存在任何疑问，都欢迎关注我们网站并咨询我们的工作人员，将竭诚为您服务。

The above is the relevant content of the question answer. I hope it can help you. If you still have any questions about this problem, you are welcome to follow our website And consult our staff, will serve you wholeheartedly.